KOP-COAT INC

PITTSBURGH, PA 15219-1818 US

Telephone: 800-553-5631, CHEMTREC 800-424-9300

Cage: 00297

MINERAL SPIRITS [MFR HAD CAS# 8051-42-3-INVALID BY BASE 10

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: <35%

TALC (CONTAINING ASBESTOS)

CAS: 14807-96-6

RTECS: MW2700000

Fraction By Weight: <20%

OSHA PEL 0.2 FIBERS/CC

ACGIH TLV: 0.2 FIBERS/CC; 9394

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: <20%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9394

MICA - SILICATES (< 1% CRYSTALLINE SILICA)

CAS: 12001-26-2

RTECS: VV8760000

Fraction By Weight: <2%

OSHA PEL 20 MPPCF; Z-3

ACGIH TLV: 3 MG/M3 RDUST; 9394

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: <20%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION OF HIGH
CONCENTRATIONS MAY CAUSE RESPIRATORY IRRITATION & CNS DEPRESSION;
PULMONARY CHANGES.CONTACT WITH EYES MAY CAUSE IRRITATION. INGESTION
MAY CAUSE GI TRACT DISTURBANCES. ASPIRATI ON MAY CAUSE PULMONARY
EDEMA; DEATH. CHRONIC: PROLONGED OR REPEATED EXPOSURE MAY CAUSE
SKIN IRRITATION OR DERMATITIS.
Explanation of Carcinogenicity:TALC (W/ASBESTOS) IS A KNOWN HUMAN
CARCINOGEN LISTED BY BOTH NTP & IARC.
Effects of Overexposure:INHALED: NAUSEA, HEADACHE, DIZZINESS,
INCOORDINATION, POSSIBLE COLLAPSE. EYES: REDNESS, TEARING, BLURRED
VISION. SKIN: REDNESS, ITCHING, DISCOMFORT. INGESTED: NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING DISEASE IN OR HISTORY
OF AILMENTS TO THE SKIN, RESPIRATORY TRACT, CENTRAL NERVOUS SYSTEM
(CNS) ARE AT GREATER THAN NORMAL RISK OF DEVELOPING ADVERSE EFFECTS
WHEN EXPOSED TO THIS MATERIAL.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITATION IF NOT BREATHING. GET MEDICAL ATTENTION IMMEDIATELY.
EYE: IMMEDIATELY FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE
HOLDING EYELID. G ET MEDICAL ATTENTION IMMEDIATELY. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING. INGESTION: DO NOT
INDUCE VOMITING. NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point:102F,39C; TCC

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED.STAY UPWIND.TAKE
UP WITH SAND OR OTHER INERT MATERIAL.FLUSH AREA WITH WATER.DIKE
AREA FOR LARGER SPILLS.CONTAIN RUN-OFF FROM FIRE CONTROL & DILUTION
WATER.THIS PRODUCT IF RELEASED MUST BE REPORTED TO 800-424-8802.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WHICH IS IN
COMPLIANCE WITH OSHA 29 CFR 1910.106. STORE AWAY FROM SOURCES OF
IGNITION AND STRONG OXIDIZING AGENTS.
Other Precautions:KEEP IN A CLOSED, LABELED CONTAINER. PROTECT FROM
PHYSICAL DAMAGE. KEEP CONTAINERS CLOSED WHEN MATERIAL IS IN USE.
MAINTAIN GOOD HOUSEKEEPING. GROUND & BOND DRUMS. DO NOT USE
PRESSURE TO EMPTY DRUMS. SPRAY PAINT IAW 29 CFR 1910.107.

Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR 1910.134 AND
MANUFACTURER'S RECO MMENDATIONS.
Ventilation:PROVIDE SUFFICIENT GENERAL/LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW TLV(S)/PEL(S).
Protective Gloves:NITRILE, NEOPRENE, OR EQUAL
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:INDUSTRIAL-TYPE WORK CLOTHING & SAFETY
FOOTWEAR; OTHER DEPENDENT ON WORK CONDITIONS. DLA-HMIS: EYE WASH
STATION.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
AVOID PROLONGED/REPEATED BREATHING OF VAPORS/FUMES/MISTS. AVOID
PROLONGED/REPEATED CONTACT WITH SKIN, EYE & CLOTHES. HANDLE & USE
IAW OSHA 29 CFR 1910.106/LOCAL CODES & REGULATIONS. MSDS ENTERED BY
DL A-HMIS UNDER PROJECT FOR GSA.

Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE

Product ID:TT-E-490E (26270 GREY)
MSDS Date:01/01/1987
FSC:8010
NIIN:01-154-2332
MSDS Number: BVQCV

Waste Disposal Methods:THIS PRODUCT IS A US EPA DEFINED IGNITABLE WASTE
(WASTE NUMBER D001). DISPOSE OF AS AN IGNITABLE HAZARDOUS WASTE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL ENVIRONMENTAL
REGULATIONS.CERCLA RQ=100 POU NDS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.